Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   KK007  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  GREAT WALL RESTAURANT Address  1545 W COURT ST
Owner or Operator   LIU, AI YIN City   KANKAKEE Zip Code   60901
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
  
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
X
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
  
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
X
1
 Wiping cloths: clean, use restricted
22
X
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
X
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
 
1
 Thermometers provided and conspicuous
37
X
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
X
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
X
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
  
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
  
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
  
5
 Toxic items properly stored, labeled and used
*12
  
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
  
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
X
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes X No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
  
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   chlorine 50-100 ppm                   Dishwasher Temperature   120-140 °F or label
Food Temperatures:   egg drop 172, rice 166, wonton 195, noodles 181, beef 183, chicken 175, pork 177, chicken 40, egg roll 38, shrimp 42
 
General Comments
 
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  09/23/2008 Time In  2:00 PM Time Out  4:00 PM Sanitation Score  86 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  90  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   KK007  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  GREAT WALL RESTAURANT Address  1545 W COURT ST
Owner or Operator   LIU, AI YIN City   KANKAKEE Zip Code   60901
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*7  Observed the following foods to be potentially contaminated. Raw chicken was stored next to beef, cooked chicken and other vegetables. Raw chicken was stored in the walk-in cooler on bottom shelf. At all times, including while being stored, prepared, displayed, served, or transported, food shall be protected from potential contamination, including dust, insects, rodents, unclean equipment and utensils, unnecessary handling, coughs and sneezes, flooding, drainage, and overhead leakage or overhead drippage from condensation. 750.150 Immediate/Onsite
2  Observed the following food products to have improper/no labeling information. There is no label on some of the food items in the walk-in cooler such as; chicken, egg rolls, wontons etc. Provide for all foods to have proper labeling information. 750.100 Next Inspection
8  Observed the following food products to be improperly stored. Chicken, egg rolls, ragoon and other food items were not covered in the walk-in cooler. Provide for all food products in storage to have proper covers or overhead protection. 750.130 Next Inspection
15  Observed the following improper non-food contact surfaces Bare wood showing on shelves in the dry storage room. Paint this shelf or re-tile shelf. Provide for all food contact surfaces to be smooth, easily cleanable, non-absorbant, corrosive resistant, and light colored. 750.690 Next Inspection
21  Observed the following wiping cloth(s) to be improperly stored: some wiping cloths are soiled and stored on tables. Store in sanitizer buckets. Provide for all wiping cloths to be stored completely submerged in an approved sanitizer solution while not being used. 750.830 Next Inspection
22  Observed the following food contact surfaces to be unclean. 1. Water was found in the reach-in cooler. Soak up all water. 2. Cutting board has a lot of food stains on it. 3. Shelves in the walk-in cooler have food debris on them. Clean and maintain. 750.800 Next Inspection
23  Observed the following contact surfaces to be unclean. Filters have grease and debris on them. Clean and maintain. 750.800 Next Inspection
36  Observed the following floor areas to be unclean: Floor has debris on it under the dishwasher. 2. Floor has food debris on it in the freezer. 3. Floor under the dry storage shelf has food debris on it. Provide for all flooring areas to be in a clean condition. 750.1220 Next Inspection
37  Obseved the following wall/ceilings, and attached equipment to be unclean: 1. Wall under the dishwasher has black mold on it. 2. Wall to the right and left of dishwasher has mold growth on it. 3. Wall in employee restroom has a hole in it. Provide for all walls, ceilings, and attached equipment to be in a clean condition. 750.1210, 750.1220 Next Inspection
     
     
     
     
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  09/23/2008 Time In  2:00 PM Time Out  4:00 PM Sanitation Score  86 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  90  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   KK007  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  GREAT WALL RESTAURANT Address  1545 W COURT ST
Owner or Operator   LIU, AI YIN City   KANKAKEE Zip Code   60901
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  09/23/2008 Time In  2:00 PM Time Out  4:00 PM Sanitation Score  86 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  90